01-04 Duramax 6.6L Juice

$519.20

100 in stock

SKU: 20000 Category:

Description

*In order to verify the LB7 motor the eighth number in the VIN should be a 1

2001 – 2004 Duramax 6.6 Liter “JUICE”

The Edge Juice is a completely weatherproof module that easily installs underneath the hood. With the addition of the Attitude monitor you can add five levels of adjustable power ranging – from 60 to 150 horsepower* – and increase torque up to 350 foot pounds*. The Juice greatly improves responsiveness and driveability, while at the same time increasing fuel economy.

The Juice communicates along the engine:s CAN-BUS data stream, from which it receives vital engine, transmission, and fuel system information. This enables the Juice to provide smooth and precise power curves that are truly custom, rather than just an offset from stock.

The Juice also monitors the transmission slippage when the torque converter clutch is engaged. The power level is decreased if any slippage is detected. This prevents damage from being caused to the transmission, and also prevents the power train from erroneously generating fault codes and entering €œlimp mode€.

The Juice also limits the amount of power increase during transmission shifts when the torque converter clutch is engaged and also when the torque converter clutch is being engaged. This allows the torque converter clutch to engage without slippage causing €œlimp mode€.

When the torque converter clutch is engaged, fifth gear on the Allison 1000 transmission will hold about 680 foot pounds of torque before slipping. Gears 2-4 with the torque converter clutch engaged have never slipped in Edge:s testing. (We have tested over 900 foot pounds of torque with no slippage). Without the sophisticated transmission monitoring that the Juice performs, the total power increase would need to be limited to the weakest conditions to prevent €œlimp mode€.

Unlike other products on the market, The Juice allows for moving power to be put to the ground under all conditions without transmission slippage or €œlimp mode€. When the torque converter clutch is engaged in fourth gear and under a heavy load, the Hot Juice should provide about 30-32 psi of boost, if the waste gate has been disabled on the turbo. Fifth gear will provide about 25-26 psi of boost when the torque converter clutch is engaged.

Brand

Stanadyne

Additional information

Weight 2.00 lbs

Reviews

There are no reviews yet.

Be the first to review “01-04 Duramax 6.6L Juice”

Your email address will not be published. Required fields are marked *